The .30-06 T44 experimental
machine gun, which combined design of FG 42 rifle and feed system of MG 42 machine gun. The T44
served as a first step in development of M60 machine gun.
M60 machine gun on integral bipod (note how gas cylinder is safe-wired to protect it from self-disassemblying)
M60 machine gun on infantry tripod
M60E3 light machine gun
US Navy SEAL fires M60E3
machine gun
M60E4 / Mk.43 mod.1 machine gun (note Picatinny rails on receiver cover and forend), and removable front grip
Like other nations which faced
German troops, the USA gave a great deal of attention to German machine
guns. Early experiments to convert the MG 42
to the US rifle calibre, carried out by the Saginaw Steering Gear
division of General Motors Corp with the T24 prototype, resulted in a
complete failure, because someone ‘forgot’ that the US .30-06 cartridge
is about 6 mm (1/4 of an inch) longer than the German 7.92mm Mauser
cartridge. Despite that setback, the US Army set out to develop a
general purpose machine gun for its troops, and in 1945 started a
series of trials to test guns developed by various state armories,
American private companies and some systems from foreign contractors. In
1946 the US Army tested the .30-06 calibre T44 machine gun, an
interesting weapon which combined features from two remarkable German
designs – the action of the FG42 machine rifle and the belt feed unit
from the MG42 machine gun. The most notable feature of the T44 was the
placement of the belt feed module, which was located on the left side
of the receiver (with the belt passing vertically from bottom to top)
instead of the more common top position with a lateral belt movement. The
development of the T44 was stopped in 1948, when it was decided to
concentrate on a new, shortened 7.62mm T65 cartridge. Work on a new
prototype, designated T52, commenced in 1947 and was continued up until
1952, when it was decided to persuade a derivative of the T52 design,
known as the T52E3, under the new designation T161. Originally
chambered in .30-06 (as a backup measure for the guns chambered for new
7.62mm T65E3 ammunition), the T161 went through several versions,
starting with the 7.62mm T161E1 and up to T161E3, which was finally
adopted in 1957 as the “machine gun, 7.62mm, M60”.
The M60
machine gun is a gas-operated, belt-fed, air-cooled weapon which fires
from an open bolt and in automatic mode only. It has quick-change
barrels with no need for headspace adjustments. Most of the steel parts
are produced using stamping and forming techniques. The M60 has a
so-called “constant volume” gas system with a short-stroke gas piston
located below the barrel. This piston has a cup shape (with the opening
facing forward) and a set of radial holes which, in the forward
position of the piston, are aligned with the gas port in the barrel.
The theory of this system is that once gas pressure in the chamber
(formed by the piston internal cavity and front of the gas block) is
enough to operate the moving parts, the holes in the piston will go out
of alignment with the gas port, cutting off the supply of high-pressure
powder gases. This also means that the system is self-adjustable and
the cyclic rate of fire cannot be easily adjusted. In practice the gas
piston could be installed improperly (with the opening pointing
rearward), turning the M60 into manually operated, single shot weapon.
The gas block also tends to unscrew itself into its component parts
under sustained fire, so its parts were often safe-wired together by
troops improvising in the field. Also, unlike many other guns, each
barrel carries its own gas block with gas piston, increasing the weight
of spare barrel kits. Locking is achieved by a rotating bolt with dual
lugs at the front. The M60 uses a belt feed with a disintegrating
steel belt running from left to right only. Feeding is of the one-stage
push-through type. The feed system of original M60 guns is built into
the hinged feed cover, and is operated by a roller-equipped stud at the
top of the bolt. The “simplified” design of the original belt feed
module required that the belt feed cover must be closed only when the
bolt is locked to the rear (cocked). If closed on the bolt in its
forward position, an attempt to cock the gun will result in damage to
the feed group. The belt is fed from 100 or 200-round boxes or soft
pouches. “Combat packs” with a 100-round belt can be attached to a
special hanger, mounted on the left side of the receiver. The
trigger and sear group along with the manual safety are incorporated
into the detachable pistol grip with an integral triggerguard. It is
attached to the bottom of the receiver by one cross-pin at the front.
The push-pin is held in place by a leaf spring, but during rough
handling and / or intense fire, the cross-pin sometimes works itself
loose, leading to the pistol grip with trigger unit becoming separated
from the weapon. This often results in a “runaway” gun, as the sear is
unable to engage the bolt and the gun fires until the ammunition runs
out or it jams. Another source of problems which also could result in a
dangerous “runaway” is the point of engagement between the sear and
operating rod. It is prone to wear and, once worn enough, the sear is
unable to stop the bolt. The standard M60 is fitted with open
sights: a ramp-type rear, mounted on the receiver, and a post-type
front, mounted on the barrel. Unfortunately the front sights are not
adjustable, so the zeroing of each barrel is made by adjustments of the
rear sight. Therefore, if a gunner desires to have all of his spare
barrels properly zeroed, he has to zero each barrel and record its
settings for the rear sight; once in combat, he has to remember to set
a proper setting for each spare barrel installed on the gun. Of course,
in real combat many gunners simply used one “combat zero” setting for
all barrels, with obvious (although insignificant in some cases)
degradation of accuracy. Original M60s are fitted with plastic
buttstocks and plastic forearms, combined with heat shields made from
stamped steel. Folding carrying handles are attached to the heat shield
close to the center of gravity of the weapon. Folding bipods are
adjustable for length and permanently attached to the barrel. This
further increases the weight of each spare barrel, and while the bipods
are intended to be used as handles during the removal of hot barrels,
the gun itself has to be held in the air by the gunner while his
assistant swaps the barrels. For sustained fire missions the M60 can
be installed on an M122 tripod (with optional T&E mechanism) and on
a variety of pintle mounts on vehicles and naval vessels.
Modifications: M60E1:
an improved version of the basic weapon, with Stellite-lined barrels, a
gas cylinder and bipod attached to the receiver instead of barrel, and
a number of other improvements. Despite its obvious advantages over
basic M60, it was never built in numbers or approved for service. M60E2: coaxial tank version, with a remote trigger and gas evacuating tube attached to the front of the gas cylinder. M60C: remotely-operated aircraft (helicopter) gun M60D:
helicopter or land vehicle weapon for flexible mounts. The plastic
buttstock and pistol grip / trigger unit are replaced with dual spade
grips and an appropriate trigger unit. A special ring sight is
installed for airborne applications. Some current versions (as made by
US Ordnance Inc) are provided with lightweight bipod for emergency
dismounted use. M60 Lightweight:
an improved version of the M60, developed during the 1970s by the Saco
division of Maremont Corp. The gas piston group is attached to the
receiver instead of barrel, and a light folding bipod attached to the
gas piston tube. The forearm and upper handguard are omitted and
replaced by a forward pistol grip. The belt feed unit is improved to
permit the safe closing of its cover when the bolt is in its forward
position. A number of other improvements were made, such as front
sights adjustable for zeroing. M60E3:
a derivative of the M60 Lightweight, sharing most of its features plus
a lightweight plastic forearm combined with a front pistol grip. In
limited use with Special Operation forces of the US Army and Navy. M60E4:
a further improvement over the M60E3, developed during early 1990s by
Saco Defence (now part of General Dynamic). Currently manufactured
under license by US Ordnance. Key improvements are: the introduction of
three styles of barrels (long / standard, short and assault), and an
improved belt feed with greater pull force for improved belt lift
capability. Several parts are redesigned and strengthened. In limited
use by the US Navy (mostly Special Operations forces). Mk.43 mod.0: designation of M60E4 in US Navy service Mk.43 mod.1:
designation of modified M60E4 in US Navy service; gun differs from
Mod.0 by having feed cover with integral Picatinny rail, plus a set of
similar rails is added to the handguard, and integral forward pistol
grip is replaced by removable vertical grip attached to the rail. --.